eISSN: 3087-4300 editor@aimjournals.com
All Journals
Submit your article

International Journal of Renewable, Green, and Sustainable Energy

Open Access Peer Review International
Open Access

Comparative Hydrodynamic Analysis of Raceway Pond Systems Using k-Ο‰ and Large Eddy Simulation Turbulence Models

DOI
PDF
Dr. Hiroshi Tanaka 1 , Prof. Yuki Nakamura 1 ,
4 Department of Robotics and Automation Engineering, Tokyo Advanced Institute of Technology Japan
4 Department of Electrical Engineering, Kyoto Institute of Engineering Sciences Japan

Abstract

Hydrodynamic behavior in raceway pond systems plays a decisive role in determining mass transfer efficiency, nutrient distribution, and biomass productivity in microalgae cultivation. This study presents a comparative computational investigation of turbulence modeling approaches, specifically the k-Ο‰ Reynolds-Averaged Navier–Stokes (RANS) model and Large Eddy Simulation (LES), for evaluating flow dynamics in raceway ponds. The research integrates theoretical turbulence modeling principles with applied computational fluid dynamics (CFD) simulations to examine velocity distribution, mixing characteristics, and energy dissipation patterns. Results demonstrate that while the k-Ο‰ model provides computational efficiency and reasonable prediction accuracy, LES captures transient flow structures and localized turbulence effects with higher fidelity. The study further analyzes how hydrodynamic variations influence system performance and identifies trade-offs between computational cost and predictive accuracy. The findings contribute to optimizing raceway pond design and operational strategies, offering insights into turbulence-driven improvements in algal cultivation systems.

Keywords

Raceway Pond, Hydrodynamics, k-Ο‰ turbulence model, Large Eddy Simulation

References

A. Al-Homoud and M. Hondzo, β€œ Energy dissipation estimates in oscillating grid setup: LDV and PIV measurements,” Environ. Fluid Mech. 7, 143–158 (2007).
E. Berdalet, F. Peters, V. L. Koumandou, C. Roldan, O. Guadayol, and M. Estrada, β€œ Species‐specific physiological response of dinoflagellates to quantified small‐scale turbulence 1,” J. Phycol. 43(5), 965–977 (2007).
M. J. Barbosa, M. Albrecht, and R. H. Wijffels, β€œ Hydrodynamic stress and lethal events in sparged microalgae cultures,” Biotechnol. Bioeng. 83(1), 112–120 (2003).
S. Campos, J. Lorca, J. Vidal, W. Calzadilla, C. Toledo-Neira, M. Aranda et al, β€œ Removal of contaminants of emerging concern by solar photo electro-Fenton process in a solar electrochemical raceway pond reactor,” Process Saf. Environ. Prot. 169, 660–670 (2023).
Y. Chisti, β€œ Biodiesel from microalgae,” Biotechnol. Adv. 25(3), 294–306 (2007).
H. Hadiyanto, S. Elmore, T. Van Gerven, and A. Stankiewicz, β€œ Hydrodynamic evaluations in high rate algae pond (HRAP) design,” Chem. Eng. J. 217, 231–239 (2013).
K. A. Hafez, O. A. Elsamni, and K. Y. Zakaria, β€œ Numerical investigation of the fully developed turbulent flow over a moving wavy wall using k–Ρ turbulence model,” Alexandria Eng. J. 50(2), 145–162 (2011).
R. Hreiz, B. Sialve, J. Morchain, R. EscudiΓ©, J. P. Steyer, and P. Guiraud, β€œ Experimental and numerical investigation of hydrodynamics in raceway reactors used for algaculture,” Chem. Eng. J. 250, 230–239 (2014).
J. Huang, X. Qu, M. Wan, J. Ying, Y. Li, F. Zhu et al, β€œ Investigation on the performance of raceway ponds with internal structures by the means of CFD simulations and experiments,” Algal Res. 10, 64–71 (2015).
J. Huang, Q. Yang, J. Chen, M. Wan, J. Ying, F. Fan et al, β€œ Design and optimization of a novel airlift-driven sloping raceway pond with numerical and practical experiments,” Algal Res. 20, 164–171 (2016).
K. Liffman, D. A. Paterson, P. Liovic, and P. Bandopadhayay, β€œ Comparing the energy efficiency of different high rate algal raceway pond designs using computational fluid dynamics,” Chem. Eng. Res. Des. 91(2), 221–226 (2013).
Q. Li, W. Du, and D. Liu, β€œ Perspectives of microbial oils for biodiesel production,” Appl. Microbiol. Biotechnol. 80, 749–756 (2008).
A. Lima, B. Marinho, and T. Morais, β€œ Hydrodynamic analysis of flow in raceway ponds for algae cultivation under versatile conditions,” Aquacult. Int. 29, 19–35 (2021).
E. Musgrove, β€œ Investigating the performance of paddlewheels used in microalgae raceways for the production of biomass,” Doctoral dissertation ( University of Southampton, 2017).
R. Pandey and M. Premalatha, β€œ Design and analysis of flow velocity distribution inside a raceway pond using computational fluid dynamics,” Bioprocess Biosyst. Eng. 40, 439–450 (2017).
T. Pirasaci, A. Y. Manisali, I. Dogaris, G. Philippidis, and A. K. Sunol, β€œ Hydrodynamic design of an enclosed Horizontal BioReactor (HBR) for algae cultivation,” Algal Res. 28, 57–65 (2017).
P. Ranganathan, J. C. Amal, S. Savithri, and A. Haridas, β€œ Experimental and modelling of Arthrospira platensis cultivation in open raceway ponds,” Bioresour. Technol. 242, 197–205 (2017).
S. Rajput, B. S. Das, and A. K. Sharma, β€œDifferent modeling approaches in increasing efficiency of raceway pond,” Fluid Mechanics and Hydraulics (HYDRO 2021), Lecture Notes in Civil Engineering, edited by P. V. Timbadiya, P. L.Patel, V. P.Singh, and B.Barman (Springer, Singapore, 2023), Vol. 314, pp. 165–177.
S. S. Sawant, H. P. Khadamkar, C. S. Mathpati, R. Pandit, and A. M. Lali, β€œ Computational and experimental studies of high depth algal raceway pond photo-bioreactor,” Renew. Energy 118, 152–159 (2018).
K. Sompech, Y. Chisti, and T. Srinophakun, β€œ Design of raceway ponds for producing microalgae,” Biofuels 3(4), 387–397 (2012).
W. H. Thomas and C. H. Gibson, β€œ Effects of small-scale turbulence on microalgae,” J. Appl. Phycol. 2, 71–77 (1990).
R. S. Voleti, See https://digitalcommons.usu.edu/etd/1307 for more details on experimental studies of vertical mixing in an open channel raceway for algae biofuel production (2012).
J. C. Weissman, R. P. Goebel, and J. R. Benemann, β€œ Photobioreactor design: Comparison of open ponds and tubular reactors,” Biotechnol. Bioeng. 31, 336–344 (1988).
B. Xu, P. Li, and P. Waller, β€œ Study of the flow mixing in a novel ARID raceway for algae production,” Renew. Energy 62, 249–257 (2014).
F. Zeng, J. Huang, C. Meng, F. Zhu, J. Chen, and Y. Li, β€œ Investigation on novel raceway pond with inclined paddle wheels through simulation and microalgae culture experiments,” Bioprocess Biosyst. Eng. 39, 169–180 (2016).

Most read articles by the same author(s)

1 2 3 4 5 > >> 

Similar Articles

1-10 of 17

You may also start an advanced similarity search for this article.